随着使用年限的不断增长，自上料水泥搅拌车都不可避免地在正常运行的过程中出现各种各样的异常故障，为了以后不再出现这样的故障，小编为您讲讲几个异常现象吧。

With the continuous growth of service life, all kinds of abnormal faults will inevitably occur during the normal operation of the self feeding cement mixer. In order to avoid such faults in the future, let me tell you some abnormal phenomena.

燃油和润滑消耗过量：

Excessive fuel and lubrication consumption:

燃油和润滑油消耗过量，表明自上料水泥搅拌车技术状况已恶化并已产生了故障。

The excessive consumption of fuel oil and lubricating oil indicates that the technical condition of the self feeding cement mixer has deteriorated and a fault has occurred.

异常响声：

Abnormal noise:

搅拌车在行驶过程中出现的非正常声响，是搅拌车故障的“报警器”。在行驶中突然发出异响，作为驾驶人应意识到搅拌车出了问题，应立即停车检查，切不可让搅拌车“带病作业”。

The abnormal sound of the mixer during driving is the "alarm" of the mixer failure. The driver should be aware of the problem of the mixer truck when it suddenly makes abnormal noise during driving, and should stop the truck immediately for inspection. The mixer truck must not be allowed to "work with disease".

渗漏：

Leakage:

渗漏是指自上料水泥搅拌车发动机的燃油、润滑油(或齿轮油)、制动液(或压缩空气)以及动力转向系油液等的渗漏现象。这也是明显的故障症状，细心观察即可发现。例如压缩空气泄漏时，可以明显地听到漏气的声音。

Leakage refers to the leakage of fuel, lubricating oil (or gear oil), brake fluid (or compressed air) and power steering system oil from the engine of the cement mixer truck. This is also an obvious fault symptom, which can be found by careful observation. For example, when compressed air leaks, the sound of air leakage can be heard obviously.

搅拌车工作状况突变：

Sudden change of mixer working condition:

所谓工作状况突变，系指自上料水泥搅拌车的工作状况突然出现不正常现象，这是比较常见的故障症状。例如：搅拌车发动机突然熄火后再启动困难，甚不能启动；搅拌车发动机在行驶中动力突然降低，行驶无力；行驶中突然制动失灵或跑偏，甚失效等。这种故障的症状明显，故容易察觉。

The so-called sudden change of working condition refers to the sudden abnormal phenomenon of the working condition of the self feeding cement mixer, which is a common fault symptom. For example, it is difficult or even impossible to start the mixer truck after the engine suddenly stops; The power of the agitator truck engine suddenly decreases during driving, and the driving is weak; Sudden brake failure, deviation or even failure during driving. The symptom of this fault is obvious, so it is easy to detect.

过热高温

Overheating high temperature

通常出现在自上料水泥搅拌车发动机、变速器、驱动桥主减速器、差速器及制动器等总成上。例如，搅拌车发动机过热，多为冷却系有问题，是缺冷却液或泵不工作；变速器和驱动桥过热，多为缺润滑油所致；制动器过热，多为制动蹄片不回位而引起。以上现象有时可以通过仪表板警示灯直接反映出来，需要驾驶人驾车时注意观察，也可以用手测试外表温度。

It usually appears on the engine, transmission, drive axle main reducer, differential and brake assemblies of self loading cement mixer. For example, the engine of the mixer truck is overheated, most of which are due to problems in the cooling system, lack of coolant or pump failure; Overheating of transmission and drive axle is mostly caused by lack of lubricating oil; Brake overheating is mostly caused by brake shoe not returning. The above phenomena can sometimes be directly reflected by the warning light on the instrument panel. The driver should pay attention to the observation when driving, and can also test the surface temperature by hand.

为保障搅拌车行驶稳定，避免不必要的维修成本，这时就需要维修人员掌握足够的维修技术，以便于在搅拌车出现故障时能进行处理。关注我们http://www.sdzkjf.cn带您了解更多！

In order to ensure the stable driving of the mixer and avoid unnecessary maintenance costs, maintenance personnel are required to master sufficient maintenance technology so that they can deal with the mixer in case of failure. Follow us http://www.sdzkjf.cn Learn more!