您好,欢迎光临莱州中科聚峰机械有限公司官方网站! 郑重声明 进入官网

自上料水泥搅拌车的皮带输送有注意事项

来源:http://www.sdzkjf.cn/ 日期:2022-05-16 发布人:zhongke
皮带输送具有输送能力强,输送距离远,结构简单易于维护,能方便地实行程序化控制和自动化操作。自上料水泥搅拌车不能缺少皮带输送机,利用皮带输送机运送物料等,因此,在使用时,也需要注意维护和保养。
Belt conveyor has the advantages of strong conveying capacity, long conveying distance, simple structure, easy maintenance, and convenient programmed control and automatic operation. The self feeding cement mixer truck cannot lack belt conveyor and use belt conveyor to transport materials. Therefore, it also needs to pay attention to maintenance when in use.
传动装置的维护与保养。使用前应加润滑油,润滑油牌号为LKC100,150#中负荷极压工业齿轮油。滚简轴承的润滑。滚简轴承为UCP系列(常用UCP214),用润滑脂润滑,每天加油一次。
Maintenance of transmission device. Add lubricating oil before use. The brand of lubricating oil is lkc100150# medium load extreme pressure industrial gear oil. Lubrication of roller bearings. The plain roller bearing is UCP series (commonly used ucp214), which is lubricated with grease and filled once a day.
滚简与托辊的清理。自上料水泥搅拌车,经常清理滚简和托辊上的积料,积料过多会影响皮带的运行,出现跑偏的情况。定期检查刮砂装置的磨损程度,刮砂装置磨损到一定程度后及时更换。橡皮挡边磨损严重,有料撒出时应及时更换。
Cleaning of roller and idler. Since the cement mixer truck is loaded, the accumulated materials on the roller and idler are often cleaned. Too much accumulated materials will affect the operation of the belt and lead to deviation. Regularly check the wear degree of the sand scraping device, and replace the sand scraping device in time after it is worn to a certain extent. The rubber retaining edge is seriously worn and should be replaced in time when materials are scattered.
接口断裂及横向撕裂的防范及处理。接头硫化处理不合格;冲击负载过大,薄弱部分受交变应力影响断裂;接口方向与皮带运动方向不合适;长期使用等,严重损坏皮带。
Prevention and treatment of interface fracture and transverse tear. The joint vulcanization treatment is unqualified; The impact load is too large, and the weak part breaks under the influence of alternating stress; The interface direction is not suitable for the belt movement direction; If it is used for a long time, the belt will be seriously damaged.
自上料水泥搅拌车
自上料水泥搅拌车在使用时要尽量减少负载,特别是有配重张紧装置的皮带,应控制配重在200kg~300kg内,以雨季不打滑为宜,加强巡查,防止异物卡死皮带,划伤皮带;加强对皮带装配人员的培训,防止皮带接口方向装反。
When using the self loading cement mixer truck, the load shall be reduced as much as possible, especially the belt with counterweight tensioning device. The counterweight shall be controlled within 200kg ~ 300kg, and it is better not to slip in rainy season. Patrol inspection shall be strengthened to prevent foreign matters from blocking the belt and scratching the belt; Strengthen the training of belt assembly personnel to prevent reverse installation of belt interface.
搅拌车在露天场地停放时,装料前应先将搅拌筒反转,把筒内的积水(或雨水)和杂物卸出,以保证运送混凝土的质量。搅拌车在空载运行及运送混凝土过程中,搅拌筒不得停止转动以免滚道、滚轮局部碰损或混凝土产生离析现象。
When the mixer truck is parked in the open field, the mixing drum shall be reversed before loading, and the ponding (or rainwater) and sundries in the drum shall be unloaded to ensure the quality of concrete transportation. During the no-load operation and concrete transportation of the mixer truck, the mixing drum shall not stop rotating, so as to avoid local collision damage of the raceway and roller or segregation of the concrete.
此外,在公路上行驶时,加长溜槽必须翻转放置在卸料溜槽上用挂钩挂牢,再转至与车身垂直部位,用锁紧装置把卸料溜槽和加长溜槽锁紧在机架上,防止由于不固定而摇动,造成伤人事故和影响其它车辆运行。
In addition, when driving on the road, the extended chute must be turned over and placed on the discharge chute, hung firmly with a hook, and then turned to the position perpendicular to the vehicle body. The discharge chute and the extended chute are locked on the frame with a locking device to prevent shaking due to instability, resulting in personal injury accidents and affecting the operation of other vehicles.
自上料水泥搅拌车的皮带输送有注意事项的相关内容就是这样了,当然定期的检查维护是必不可少的,希望对大家有所帮助。更多内容就来网站www.sdzkjf.cn进行咨询吧。
This is the relevant content of precautions for belt conveying of self feeding cement mixer truck. Of course, regular inspection and maintenance are essential. I hope it will be helpful to you. For more information, please visit www.sdzkjf.com Cn for consultation.

上一篇:自上料水泥搅拌车的维护工作以及选购原则
下一篇:水泥自动搅拌车驾驶员安全技术操作规程