水泥自动搅拌车在要做进、出料作业而离开驾驶室时，务请完全锁定制动器，并同时设定好车轮的制动器，然后再进行作业。下面就来讲讲搅拌车一般作业时的重要注意事项还有什么吧。

When the automatic cement mixer leaves the cab for feeding and discharging, please fully lock the brakes and set the brakes of the wheels before operation. Now let's talk about the important precautions for the general operation of the mixer truck.

进行清洗、加油、加润滑油脂等作业时的重要注意事项为防止在拌筒运转时，发生卷入拌筒驱动部件(拌筒、托轮、驱动轴)及其他运转部件的危险，当发动机停止进行以下作业时，操作杆须置于“停止”。并将发动机熄火。发动机钥匙拨出后，一定由操作者携带，以免发生人身事故。

Important precautions for cleaning, oiling, greasing and other operations to prevent the danger of being involved in the driving parts of the mixing drum (mixing drum, supporting wheel, driving shaft) and other operating parts when the mixing drum is running. When the engine stops the following operations, the operating lever must be set to "stop". And shut down the engine. After the engine key is removed, it must be carried by the operator to avoid personal accidents.

⑴对粘附在进料斗，拌筒筒口，拌筒托轮，后车架，拌筒刮桨板口的混凝土进行冲洗及铲除作业时。

(1) when washing and eradicating the concrete adhered to the feed hopper, mixing drum mouth, mixing drum supporting wheel, rear frame and mixing drum scraper plate mouth.

⑵对拌筒、拌筒托轮、减速器、操作控制杆件、驱动轴等进行检修，以及加油、加润滑脂和换油时。

(2) overhaul the mixing drum, mixing drum supporting wheel, reducer, operation control rod, drive shaft, etc., and add oil, grease and oil.

⑶在平坦地带作业时，请将车轮制动闸完全锁定后再进行作业。

(3) when working in a flat area, please lock the wheel brake completely before working.

进行拌筒内混凝土等的铲除作业时的重要注意事项在拌筒内进行铲除等作业时，务请遵守以下事项。

Important precautions for the removal of concrete in the mixing drum. Please observe the following when removing concrete in the mixing drum.

（1）防止拌筒转动的操作顺序

(1) Operation sequence to prevent the mixing drum from rotating

①后部操作手柄确实置于空档位置。

① The rear joystick is indeed in the neutral position.

②停止发动机。

② Stop the engine.

③拔出发动机的钥匙，由操作人员携带保管。

③ Pull out the key of the engine and keep it by the operator.

④将清楚写有“拌筒内有人工作”的牌子，竖立在外面显而易见的地方。

④ A sign clearly stating "someone is working in the mixing drum" shall be erected in an obvious place outside.

⑤在拌筒内作业时，务必对拌筒采取防止转动措措施。

⑤ When working in the mixing drum, measures must be taken to prevent rotation of the mixing drum.

（2）铲除作业时的注意事项

(2) Precautions during eradication operation

①应左右对称地一点一点地进行。

① It should be carried out symmetrically from left to right, bit by bit.

②应在粘附的混凝土并不多时就进行。每次使用完后都应清洗拌筒内部。

② It should be carried out when the adhered concrete is not much. The interior of the mixing drum shall be cleaned after each use.

③万一粘有大量混凝土时，请将粘着部位置于正下方。

③ In case of a large amount of concrete, please place the adhesive part directly below.

注意：紧固螺栓时，切忌过紧。检修完后，检修孔盖板的密封圈上应均匀地涂抹一层油灰，然后方可安装。更多注意事项就来我们网站http://www.sdzkjf.cn进行咨询吧。

Note: do not tighten the bolts too tightly. After maintenance, a layer of putty shall be evenly coated on the sealing ring of the manhole cover plate before installation. Come to our website for more precautions http://www.sdzkjf.cn Let's consult.