您好,欢迎光临莱州聚峰机械有限公司网站! 郑重声明 进入官网

水泥搅拌车液压输送的常用知识

来源:http://www.sdzkjf.cn/ 日期:2021-06-10 发布人:admin
水泥搅拌车是很常见的一种工程车,那么对于液压输送常识你知道多少呢?水泥搅拌车出料完毕应立即用随车的软管放水将进料口、出料斗及出料溜槽等部位冲洗干净,排去粘结在车身各处的污物及残留混凝土,再向搅拌筒内注水150-200L的清水,在返回途中要让搅拌筒慢速转动,以清洗内壁,避免残余料渣附在筒壁和搅拌叶上,并在再一次装料前将这些水放掉。
Cement mixer is a very common engineering vehicle, so how much do you know about hydraulic conveying? After the discharge of cement mixer, immediately flush the inlet, outlet hopper and discharge chute with the hose attached to the truck, remove the dirt and residual concrete adhered to the body, and then inject 150-200l clean water into the mixing drum. On the way back, let the mixing drum rotate slowly to clean the inner wall, so as to avoid the residual slag adhering to the wall and mixing blade, And discharge the water before loading again.
水泥搅拌车运送混凝土水泥的时候,发动机转速在1000-1400转/分范围内工作,以使发动机有扭距,在运送水泥过程中,车速不得超过40km/h,以保行车。
When transporting concrete, the engine speed of cement mixer should be in the range of 1000-1400 rpm to make the engine have the maximum torque. In the process of transporting cement, the speed should not exceed 40km / h to ensure driving safety.
水泥搅拌车工作完毕,应把搅拌筒内部和车身清洗干净,不能使剩余的混凝土留在筒内。
After the cement mixer is completed, the inside and body of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the drum.
水泥搅拌车在水泵工作时,禁止空转,连续使用时不要超过15分钟。
When the water pump is working, the cement mixer is not allowed to run idle, and the continuous use should not exceed 15 minutes.
水泥搅拌车水箱的水量要经常保持装满,以备急用,冬季停机后,应将水箱、水泵、水管、搅拌筒内的水放净,并停放在朝阳、不积水的地方,以免冻坏机械。
水泥自动搅拌车
The water in the water tank of the cement mixer should always be kept full for emergency use. After stopping in winter, the water in the water tank, water pump, water pipe and mixing drum should be drained, and the water should be parked in the sunny place without ponding, so as to avoid freezing the machinery.
搅拌车在冬季应及时安装保温套,并使用防冻液对搅拌车加以保护,根据天气变化更换燃油标号,确保机械的正常使用。
In winter, the mixer should be installed with insulation sleeve in time, and use antifreeze to protect the mixer. The fuel label should be changed according to the weather change to ensure the normal use of the machinery.
在检查、修理水泥搅拌车液压传动部分时,应使发动机和液压泵在没有压力的情况下进行。
When inspecting and repairing the hydraulic transmission part of cement mixer, the engine and hydraulic pump should be operated without pressure.
在调整水泥搅拌车各部间隙、行程、压力时,应由专职员检查同意;更换机件时,必须由部长或主管经理签字,否则出现问题后追究有关人员责任。
When adjusting the clearance, travel and pressure of each part of the cement mixer, it should be checked and agreed by the full-time safety officer; When replacing the machine parts, it must be signed by the minister or the manager in charge, otherwise the relevant personnel will be held responsible after the problems occur.

上一篇:小水泥搅拌车故障紧急要点在哪?
下一篇:水泥搅拌车液压输送的常用知识